Volvo S60 – All

Recommended every 6 months.

Service Includes:

• Oil change
• Oil filter change

Recommended every 12,000 miles or 12 months.

Service Includes:

Pre engine checks

• Check for damage to bodywork, lamps and trims.
• Lubricate all door hinges, locks and bonnet catch.
• Check condition and operation of all seat belts.
• Check operation of interior and exterior lights.
• Check operation of ABS and/or air bag warning lights.*
• Check windscreen washers and wipers.
• Check horn.
• Check operation of suspension dampers.

Under the bonnet

• Check and top up engine oil.
• Check and record brake fuel fluid condition.
• Check all auxiliary drive belts (not timing belt).
• Check power steering operation and fluid condition.
• Check battery level and lubricate terminals.
• Check and top up all under bonnet fluid levels.
• Check and record antifreeze protection.
• Check cooling system for leaks, cooling fan operation and heater output.
• Check the condition and security of the exhaust.
• Carry out tyre report.

To finish

• Road test vehicle and report and findings.
• Ensure upholstery, gear lever, steering wheel, etc. are clean.
• Stamp service book.

*where appropriate

Recommended every 24,000 miles or 24 months.

Service Includes:

Pre engine checks

• Check timing belt replacement interval.*
• Check for damage to bodywork, lamps and trims.
• Lubricate all door hinges, locks and bonnet catch.
• Check condition and operation of all seat belts.
• Check operation of interior and exterior lights.
• Check operation of ABS and/or air bag warning lights.*
• Check windscreen washers and wipers.
• Check horn.
• Check operation of suspension dampers.
• Check air conditioning operation including bad odour.*
• Check fuel cap.

Under the bonnet

• Check and record brake fuel fluid condition.
• Check all auxiliary drive belts (not timing belt).
• Check power steering operation and fluid condition.
• Check battery level and lubricate terminals.
• Check and top up all under bonnet fluid levels.
• Check and record antifreeze protection.
• Check cooling system for leaks, cooling fan operation and heater output.
• Check engine breather system.
• Check vacuum pipes.
• Check throttle body. Clean if required.
• Replace air filter.*
• Replace spark plugs.*
• Replace fuel filter.*
• Replace pollen filter.*
• Carry out tyre report.

Vehicle Raised

• Change oil, filter and fit new sump plug washer.
• Check fuel lines and brake pipes.
• Check the condition and security of the exhaust.
• Check and top up axle and transfer box oil levels.*
• Check and top up gearbox oil levels.*
• Check all steering and suspension joints, mountings and gaiters.
• Check all wheel bearings for excessive ‘play’ and noise (adjust).
• Check CV gaiters and joints for wear or splits.
• Check clutch cable/cylinder.*
• Grease all greasing points.*
• Check operation and condition of front brakes.
• Check operation and condition of rear brakes (inc. handbrake).
• Carry out brake report.

Vehicle Lowered

• Refill engine with specified grade oil.
• Torque wheel nuts/studs.

To Finish

• Road test vehicle and report any findings.
• Re-check engine oil level.
• Reset service interval indicator.*
• Ensure all upholstery, gear lever, steering wheel, etc. are clean.
• Stamp service book(s).

*where appropriate